• 1 – 20 t/h
  • 0.7 – 2 Mpa
  • Industrial
  • In Stock
  • Nature gas, coke oven gas, biogas, methanol, liquid propane gas, diesel, heavy oil, light oil, crude oil, etc.
  • Heat supplying, chemical, food, textile, printing and dyeing, cigarettes and tobacco, fodder, pharmacy, building materials, brewery, rubber, hospital etc.

WSN series gas / oil fired industrial horizontal steam boiler is a kind of safety and high efficiency heating equipment with fully automatic intelligent control system. It’s a boiler shell type 3 passes wetback oil/gas fired boiler. Usually, the WNS series steam boilers widely used for industry production and processing, such as textile mill, medicine industry, food & beverage industry, chemical industry, garment industry, food processing industry, and wood processing industry, moreover, it could be used for central heating in enterprise, hotel, hospital, civil architecture, etc.

Gate valve or Ball Valve? — Heating Help: The Wa

Gate valve or Ball Valve? I need to replace that cobbed in piece of Galvanized on the return. You can see the rust spot towords the top and it is about paper thin. I am also going to replace the fittings below. As per the advice I received on the wall I want to redo the water lines and get it off of the softend water. And run some copper.

Gate valve or Ball Valve? — Heating Help: The Wa

Gate valve or Ball Valve? For high pressure steam a really good quailty s/s valve is needed and be careful not to let it wiredrawing which will cut the valve and/or seat out in no time. (Steam PRVs on deaerators would be valves in throttling service.) Steam boiler gauge glass & water column blowdown, and bottom blow down won't fall into

CLEAVER-BROOKS - cbboilers.c

2010-8-25 · CLEAVER-BROOKS Model CB, CB-LE Packaged Boiler 400 - 800 HP, Light Oil, Heavy Oil, Gas, or Combination CB-LE Packaged Boiler Manual 6.30 — Steam Heater Pressure Regulator (400 and 600 Series: Steam) 6-35 CHAPTER 7 Troubleshooting 7-1 8.18 — Fuel Oil Metering Valve, Adjusting, Relief Valves 8-23

MARINE ENGINEERING KNOWLEDGE BY RAJAN -

Closed main steam stop valve. Increase cut off pressure of boiler. Bypass high pressure cut off of the boiler. Arrange the boiler fire rate to a maximum. Safety valve will be lift during the test. The test is carried out as long as the water permits in the boiler. Accumulation pressure should not exceed 10% of working pressure in the specified

Some Criteria for Choosing a Steam Boiler for a

2016-6-9 · the selection of a boiler for a small brewery. A low pressure steam boiler is an ASME Code Section IV Boiler stamped for 15 PSI. It can be operated up to 13- 14 PSI maximum. A high pressure steam boiler is a Section I boiler and they are usually stamped for 100, 125 or 150 PSI. There is a direct correlation between steam pressure and temperature.

ICB Specifications - Ste

2018-8-5 · • 400 – 800 hp. Fuel oil piping on the unit shall include oil metering system, one (1) solenoid oil shut-off valve, one (1) motorized oil valve with proof of closure switch, pressure relief valve, atomizing air proving switch, and low oil pressure switch all integrally mounted on the unit. e. Oil Atomization Type — Select one of the

Boiler Operation and Controls - Wiki - odesie by Tech

The '''steam heater supply check valve''' is installed in the steam supply line ahead of a steam oil heater, the check valve prevents oil contamination of the waterside of the pressure vessel should any leakage occur in the oil heater. The '''steam heater pressure regulator''' is used on steam boiler units that operate at pressures higher than

MODEL CBR PACKAGED BOILER - Waterloo Manufacturi

Manual Part No. 750-225 4/07 MODEL CBR PACKAGED BOILER 125 through 800 hp Fuel: Light Oil, Heavy Oil, Gas or Combination

CLEAVER-BROOKS MODEL PACKAGED BOILE

2019-11-23 · H. Slowdown-Steam Boiler 2-10 . I. Periodic Inspection 2-13 . J. Preparation for Extended Lay-up 2-14 . Steam Heater Pressure Regulator (400 and 600 Series-Steam) 5-25 . N. Fuel Oil Metering Valve, Adjusting and Relief Valves . 7-13 0. The Air Pump and Lubricating System .

Pressure And Output Limitations Of Shell Type Boile

This boiler is horizontal type,fire tube,three pass shell boiler.It can burn heavy oil,light oil,city gas,natural gas,lpg,lng,cng(depend on the burner selected).Boiler furnace is corrugated furnace,burning under positive pressure,fully 14MW LNG hot water boiler Industrial steam boiler 14MW RFOindustrial boiler Gas Boilers Supplier

How to Set Hot Water or Steam Heating System

How to Set Hot Water or Steam Heating System Pressure & Temperature. Heating System Pressure and Temperature Controls What are normal hot water heat pressure & temperature settings ? What are normal residential steam heat pressure & temperatures ? Where & how do I set the boiler pressure & temperature controls? Where & how do I set a steam boiler pressure & temperature?

ModelRated steam capacity(t/h)Rated working pressure(Mpa)Rated steam temperature(℃)Maximum transport size(m)
(L×W×H)
WNS1-0.7-Y(Q)10.71703.3×1.8×2.1
WNS1-1.0-Y(Q)111843.3×1.8×2.1
WNS1.5-1.0-Y(Q) 1.511843.0×1.8×2.0
WNS1.5-1.25-Y(Q)1.51.251943.0×1.8×2.0
WNS2-1.0-Y(Q) 211844.4×2.1×2.5
WNS2-1.25-Y(Q)21.251944.4×2.1×2.5
WNS3-1.0-Y(Q)311844.6×2.3×2.6
WNS3-1.25-Y(Q)31.251944.6×2.3×2.6
WNS4-1.25-Y(Q)41.251944.7×2.5×2.9
WNS4-1.6-Y(Q)41.62044.7×2.5×2.9
WNS5-1.25-Y(Q)51.251945.3×2.7×3.3
WNS5-1.6-Y(Q)51.62045.3×2.7×3.3
WNS6-1.25-Y(Q)61.251945.9×2.6×3.0
WNS6-1.6-Y(Q)61.62045.9×2.6×3.0
WNS8-1.25-Y(Q)81.251945.9×2.8×3.1
WNS8-1.6-Y(Q)81.62045.9×2.8×3.1
WNS10-1.25-Y(Q)101.251947.7×2.8×3.1
WNS10-1.6-Y(Q)101.62047.7×2.8×3.1
WNS15-1.25-Y(Q)151.251947.0×3.1×3.6
WNS15-1.6-Y(Q)151.62047.0×3.1×3.6
WNS20-1.25-Y(Q)201.251948.3×3.4×4.0
WNS20-1.6-Y(Q)201.62048.3×3.4×4.0